insulation heat tank Sad
Post Reply   Forum
Posted by: jc
Huckleberry
03/03/2006, 07:03:18

Author Profile eMail author Edit

could anyone can tell me any insulation can be wrapped on band heater? The insulation shall able to stand at 550C, meet to california state prop 65 law, no environmental issue, No cause Lung cancer, no airborne issue. The usage of insulated band heater is to prevent heat loss and saving electrical energy. The band heater is wrapped at a 1.2L water tank.







Post Reply | Recommend | Alert Administrator View All   | Next |

Replies to this message


Re: insulation heat tank Smile
Re: insulation heat tank -- jc Post Reply Top of thread Forum
Posted by: Scooter

03/14/2006, 08:12:18

Author Profile eMail author Edit

If fibers are not exceptable, I suggest strips of polyuerathane ridgid insulation. Lay the strips then wrap with a good grade of Duct tape.







Post Reply | Recommend | Alert Administrator Where am I? Original Top of thread | |
Re: insulation heat tank Disagree
Re: Re: insulation heat tank -- Scooter Post Reply Top of thread Forum
Posted by: Scooter

03/14/2006, 09:06:08

Author Profile eMail author Edit

P.S. to Topec & Scooters comments, I forgot to mention that the polyuerthane may not be able to withstand the heaters outside tempiture. Check this out prior to concederation of this material being used.

Thanks,
scooter








Post Reply | Recommend | Alert Administrator Where am I? Original Top of thread
Re: insulation heat tank
Re: insulation heat tank -- jc Post Reply Top of thread Forum
Posted by: zekeman

03/03/2006, 22:05:08

Author Profile eMail author Edit

Fiberglass covered with aluminum foil, standard insulation fot vent ducts.







Post Reply | Recommend | Alert Administrator Where am I? Original Top of thread | |
Re: insulation heat tank
Re: Re: insulation heat tank -- zekeman Post Reply Top of thread Forum
Posted by: jc
Huckleberry
03/03/2006, 22:12:24

Author Profile eMail author Edit

Our customer didn't like the fiber glass even wrapped with a layer of alum. They claimed that it will airborne if it was wrapping unproperly. Meanwhile, the service man will inhale the fiber glass when it airborne. Most of the fiber are not accepted by our customer unless we can proof them it save for human being in all spec.







Post Reply | Recommend | Alert Administrator Where am I? Original Top of thread

Powered by Engineers Edge

© Copyright 2000 - 2019, by Engineers Edge, LLC All rights reserved.  Disclaimer